Safety 1st Advancer Instrukcja Operatora Pobierz pdf (Strona 132)

Environmental Remediation Drilling

Safety Guideline

Page 132 of 132

Attachment 5.B - Typical Job Safety Analysis for Equipment Loading and Unloading

Job Being

Analyzed:

LOADING AND UNLOADING BACKHOE/FORKLIFT

Date

Started:

Instructions: load and unload in dry even area. Watch for lift sliding on ramps, to close to the side, lift in right gear

FLAT AND LEVEL WORK

STEPS HAZARDS PREVENTION

1. Check area for hazards Uneven ground, wet obstruction

Park on dry flat area with nothing in

the way

2. Try to have a spotter

Vision not being able to see where you

are

Spotter - to check closeness to

sides and ramp

3. Verify truck is in gear with brake

and wheels chalked

Truck and trailer could move when

loading or unloading

Leave in gear, brake on and wheels

chalked

4. Check hitch Hitch coming loose when loading

Check hitch, verify it is locked with

pin and safety chain is attached

5. Loading

Weather can make lift slide on ramps

and trailer

Load in dry, level area - use 4-

wheel drive, low gear: watch and be

aware

6. Ramps

Not even, pins loose: raise and lower

properly

Check ramps before lowering and

when raising lift properly

7. Tying down

Mast too high, not enough chains, in

gear with brake on and wheels

chalked

Check mast height: use 4 chains

tying down, chalk wheels, check

load after driving a few miles

8. Unloading - same steps in

reverse, check

lift, verify it is in good condition

9. Check forklift

Brakes out of adjustment popping out

of gearing, shutting off emergency

brake

Check out before loading and

driving off lift, oil levels

10.

11.

Comments:

If off unloading with forks, fwd insure forks are high enough for fork clearance

Complete forklift inspection

Do not load/unload equipment with engine running

OPERATOR SAFETY COMMITTEE:

Operator 1: Operator 2: Operator 3:

Management 1: Safety Director: Guest:

1 2 ... 127 128 129 130 131 132

Komentarze do niniejszej Instrukcji

Brak uwag

Safety 1st Advancer Instrukcja Operatora Strona 132

Komentarze do niniejszej Instrukcji

Powiązane produkty i podręczniki dla Wózki dziecięce Safety 1st Advancer